Filter
Top Products
Version: 6.0
18
DOOR(S) INSTALLATION
The Inglenook doors have been mounted and checked for proper fit at the factory. If the doors are
removed for any reason, care must be taken in reinstalling the doors to ensure proper alignment and
fit. Setting the doors is quite simple. Ensure the doors are in the fully open position and then align
the female portion of the door hinge with the male portion of the fireplace hinge. Gently lower the
door hinges over the fireplace hinge. Once proper seating has been accomplished, the door can be
closed to check for proper fit. Follow the same procedure for the second door. The Inglenook door
installation should now be complete. To remove the doors, simply lift up a door from the fireplace
hinges. Store both doors in a secure place. If the doors are left sitting, ensure that the doors cannot
fall and injure someone or damage the door or glass by falling over. The Inglenook doors have been
adjusted at the Country Flame factory. If the door fit is not satisfactory, the owner can adjust the
doors using the hinge screws, refer to Figure 7.
FIGURE 7: DOOR ALIGNMENT POINTS
DOOR(S) ADJUSTMENT
The Inglenook doors, if installed and shipped with the fireplace, may require fine adjustment due to
shipping vibrations and jarring. After extended use, the door may also require some minor
adjustments to maintain a center-aligned appearance. The Inglenook doors need to remain airtight to
ensure proper firebox operation. The door gasket air tightness can be adjusted. To adjust the gasket
tightness, simply rotate the right hand door latch clockwise (tighten) or counterclockwise (loosen) one
complete revolution or as necessary to adjust the gasket seal. A good test to evaluate proper door
gasket seal is to lay a dollar bill against the stove frame and then close and latch the door. If gently
tugging on the dollar bill dose not dislodge it from the door, the seal is appropriate.
GLASS REPLACEMENT
The glass used in the Inglenook Fireplace is a 1400 degree Fahrenheit (° F) high temperature ceramic
glass. If the glass should crack or break for any reason, it must be replaced with an equal or better
grade ceramic glass. The use of tempered glass or ordinary glass IS NOT AUTHORIZED and is